SERVICE MANUAL
  Applies to: Hyundai Coupe/Tiburon 1998-2001
GROUP
Body (Interior & Exterior) General
Return to Main Menu(s):      Mechanical Manual      Electrical Manual

TROUBLESHOOTING 
Symptom
Probable cause
Remedy
Sunroof water leaks
Dust accumulated in drainage of housing assembly
Clear dust from inside, of drain pipe

Clogged drain pipe
Blow air into drain pipe to remove dust

Broken or dislocated drain pipe, defective or cracked clip
Check pipe installation and flange contact

Deteriorated roof lid weatherstrip
Replace

Excessive roof lid-to-body clearance and improperly fitted weatherstrip
Adjust
Wind noise
Loose or deformed deflector
Retighten or replace
Roof lid makes noise when moved
Foreign matter lodged in guide rail
Check drive cable and guide rails for foreign matter

Loose guide rails and lid
Retighten
Motor runs but lid does not move or moves only halfway
Foreign matter lodged in guide rail
Check drive cable and guide rails for foreign matter

Incorrect engagement of motor pinion with drive cable
Check for loose motor installation and damaged pinion

Decrease in clutch slipping force of motor
Adjust

Increased lid sliding resistance or interference of lid with drive cables, weatherstrip, etc. due to maladjustment of lid
Adjust or replace
Noise in motor (Clutch slipping noise made in motor when lid is fully opened or closed is not unusual noise.)
Incorrect engagement of motor pinion with drive cable
Check pinion installation and retighten motor

Worn or damaged motor pinion bearing
Replace motor assembly

Worn or deformed drive cable
Replace
Door glass fails to operate up and down
Incorrect window glass installation
Adjust position

Damaged or faulty regulator arm or regulator
Correct or replace
Door does not open or close completely
Incorrect door installation
Adjust position

Defective door check
Correct or replace

Door hinge required grease
Apply grease
Hood does not open or close completely
Striker and latch not properly aligned
Adjust

Incorrect installed hood
Adjust

Incorrect hood bumper height
Adjust
Water leak through windshield and rear window
Defective seal
Fill with sealant

Defective flange
Correct
Wind noise around door
Weatherstrip not holding firmly
Adjust fit of door

Improperly installed weatherstrip or setting of weatherstrip setting of weatherstrip
Repair or replace

Improperly closed door
Adjust

Improperly fit door
Adjust

Improper clearance between door glass and division channel
Adjust

Deformed door
Repair or replace